Silver Wings Then Other Things: Part 3

This is Part 3 of the series putting you in the captain’s seat.

Want to start at the beginning? Click here.

.

.

I love the smell of jet fuel in the morning.

Okay, maybe right before noon–I don’t bid early flights and since I’ve been here over 25 years, I don’t have to do the buttcrack of dawn flights anymore. But it all leads to the same place: ready for take-off.

And whether that’s your first solo or your most recent take-off line-up, it’s the best part of the world ever: nose pointed down the line, strapped in tight, slight bend at the knees so as to have easy rudder throw in either direction, holding brake pressure on top of the rudder pedals, waiting for release.

Calm. All the engine instruments are flat-lined like a comatose patient, breathing; heartbeat but not much else. Idle RPM on both the giant fan and the turbine.

These new jet engines are mechanical and technological marvels, gi-normous Swiss watch-like machines: tolerances to the thousandth of an inch, spinning at 30-50,000 RPM for hours, tirelessly, core temps averaging blast furnace heat all the while. Each engine weighs over two tons, but puts out 27,000 pounds of thrust, so with both at full power, you have 26 tons of thrust at your fingertips for take-off or whenever you need it.

The pair of CFM-56 engines will gulp down nearly a thousand gallons of jet fuel between take-off and level off, but the marvel is, even heavy-weight we’ll climb to 38,000 feet in about fifteen minutes.  That’s also attributable to the Boeing wing: they were wise enough to increase the size of the wing as they stretched the airframe. Not so with Douglas jets like the DC-9–they just added length to the fuselage and kept the original wing.

I like the feel of the fat, swept and cambered-up Boeing wing, which as a result of the lengthening has a lighter wing-loading than the stretched Douglas.

It just feels more stable and reliable both in the low-speed regime and almost more importantly, at altitude. So on take-off, there’s just a confidence you can bank on with the Boeing: it has power and lift to spare.

“Cleared for take-off” are the words you’re waiting for. Once you gang-bar the exterior lights, the First officer will call, “Before take-off checklist complete.”

You stand the throttles up and immediately, the CRT displaying engine instruments springs to life. The computers below the flight deck measure the throttle position and project where the RPM of both the giant fan and the subsequent rotors will be in a matter of seconds. They stabilize at 40%, then the actual rotor speed catches up as the engines snarl to life. Satisfied at 40%, I punch the take-off power button on the throttles and they move to the position that the engine computers say matches the temperature and the other parameters we programmed and will produce the thrust we’re expecting. I double check that they are within 2% of what I expect, then turn my eyes to the runway stretched out ahead.

It’s best to cast your eyes way down the runway so as to have a good peripheral awareness: engine failures will be most obvious from the initial yaw, plus, directional control at over a hundred miles per hour is best judged with a long view.

Now I’m steering with the rudder pedals, trying to just nudge the nosewheel–stay off the centerline lights with their annoying thumping–until between forty and seventy knots when the forty-foot tall rudder takes a good enough bite of the air to become effective at aerodynamic control.

“Eighty knots,” is the first callout, and it comes fast at take-off power. That’s the abort dividing line: up till eighty, I can consider aborting for various systems problems. After eighty, the abort response is different and because of the kinetic energy built up in our 70-ton freight train, stopping is much more critical a maneuver with serious consequences in terms of brake energy.

Plus, it’s not wise to try to arbitrate at over a hundred miles per hour whether a system indication stems from a failure that would affect our ability to stop: brakes, anti-skid, hydraulics, electrics.

That’s why I’m relieved when the aircraft announces “V1.” That means we’re beyond abort speed–and I’m thinking only of flying, even on just one engine if need be.

Almost immediately, the First Officer calls,”Rotate” and I ease the yoke back gently. Have to let the 737 fly off  and get some tail clearance from the pavement before smoothly rotating the nose up to take-off pitch, which is shown in my heads-up display (HUD). Off we go.

When I see vertical velocity climbing in the HUD, plus increasing radio altitude numbers, I simultaneously give the hand signal  (flat open right palm moving up) and say, “Positive rate–gear up.” The hand signal is in case my voice is blocked by radio chatter or other extraneous noise.

The HUD’s also showing me the energy building on the wing, plus the speed trend. Call for the flaps up before the limit speed, engage vertical navigation (“V-Nav”) at 2500 feet. Track the departure outbound, centering up the radial. I sneak peaks down from the HUD to the Nav display so as to anticipate the turns ahead. Roll into the turns easy–the 737 flies really tight and responsive–and carve out a smooth arc.

First milestone: ten thousand feet. Roll in some nose-down trim so as to accelerate beyond the 10,000′ limit of 250 knots. A quick check to be sure that the cabin is climbing and that fuel is flowing properly: above 10,000′ we can burn center tank fuel if we didn’t on take-off or if there was less than 5,000 pounds at take-off; less than 3,000 pounds now and you reach up and open the fuel crossfeed manifold and turn off the aft fuel boost pump.

Eyes back on the road. Trim. Smoothness. Coffee.

Before you know it, the chronometer says around 18 minutes elapsed time and the altimeter reads 40,000 feet. Trim it up, level and smooth, trim out any yaw, engage the number 1 autopilot. Check the fuel burn, the fuel flow and the quantity. Cabin pressure stable at the correct differential value. Nav tracking properly. Cool: we’re cruising.

So now, here’s you:

No, not just punching the time clock–counting fuel flow, measuring miles remaining against fuel and miles per minute. Print the uplink of the destination weather. Was your forecast correct? No, you didn’t do the weather forecast–you predicted what fuel you’d need on arrival for the approach in use. Kind of glad to have a little extra in the hip pocket, right? Conservative fuel planning.

Note the climb point and more importantly, the gross weight where that can occur. Pay attention; note when it arrives early and use it: tailwinds or headwinds shift the point, but track the weight.

Now it’s time for the P.A. Nobody cares or pays attention–especially the flight attendants who will ask “what’s our ETA” even though you just announced it. Whatever. It’s always partly cloudy, make up a temperature, read off the latest ETA, “glad to have you flying with us today; for now, sit back, relax” blah-blah blah, get ready for the approach.

Uplinked destination weather.

You know the arrival winds. You got the uplinked current weather and terminal information. Set up the approach in the course windows and frequency selectors. Yes, it can change while you’re enroute, but now is the time to set up the approach and get it straight in your head.

There’s the art in what you do: translate this schematic into three dimensional movement in pitch, bank and roll. Each approach has its own peculiarities–so start thinking it through now.

Meanwhile, however, just a constant flow of navigation, fuel flow and performance considerations. Keeping a fuel and navigation log, constant contact with Air Traffic Control:

That and maybe some of the catering from First Class provisioned as “Crew meals.”

The best catering of breads and desserts is out of Mexico and Canada, I think. But at any rate, it’s probably good to stay “calorized”  as a survival tool: time changes, sleep disruptions, long hours, extremes of climate and especially the prolonged hours in a low-humidity cabin–it all takes a toll, physically. And flight crews work in that realm week after week. At least you can buttress your health with the caloric energy you need. It’s not always available between flights.

Manage the fuel. Weather radar and traffic watch. Ride and wind reports, both from other aircraft and uplinked from our Ops center. navigation–course modifications, shortcuts, direct clearances, higher altitudes when we’ve burned off enough fuel.

So it goes for hours on end.

The nav systems are plotting a descent already. They have drawn an imaginary line from altitude to our destination and I can see constantly the angle and the rate of descent changing as we draw nearer. I’m going to induce the descent–with ATC clearance, of course–a little early, maybe fifteen miles or so depending on winds, to make the descent a little flatter and more comfortable in the cabin. Besides, the automation doesn’t account for ATC restrictions added to those already published. Let’s get ahead of the game.

HEFOE Check: Hydraulics, electrics, fuel, oxygen, engines; periodic checks, the mantra from the Air Force days–nostalgic, but appropriate still in an airliner at the top of descent. Which, I’ve decided in my mental picture of the descent angles, distances, speeds and times, is now.

“Tell them we’d like lower,” I say to the First Officer. He nods, instinctively aware that it’s about time to start our descent. This is where passengers in the cabin notice the slight decrease in engine noise and a bit of a nose-down tilt.

The shoulder harness come back on in the cockpit; headsets replace overhead speakers and boom mikes take over from the hand mikes. Approach plates are reviewed on more time; crossing altitudes and speeds, intercepts and radials. This is the fun part: translate the myriad of plotted out instructions into a graceful series of maneuvers culminating with a safe touchdown, then dissipating the kinetic energy of sixty tons thundering down the runway at about one hundred and sixty miles an hour, bringing the whole remarkable aircraft to walking speed, then to a gentle stop at the gate. Piece of cake.

Next week, Part 4: the approach and landing.

Silver Wings, Then Other Things: Part 2.

This is part 2 of a multi-part series putting you in the captain’s seat. Want to start with Part 1? Click here.

.

.

Flight plan? Got it. Fuel load? Fine. Take-off data? Got that too. The ten-yard-long printout of notices and info and weather affecting our flight and route? Folded accordian style. Cup of McDonald’s coffee, black? In the cupholder by your right knee.

Something about that: a simple pleasure, that black coffee, plus an opportunity to make a donation to the Ronald McDonald House at the counter every time. I like the idea of doing something good for kids every time I pass by McD’s in the airport.

But also, in “the bubble,” it’s a cool luxury: taxiing out, steering with feet on the rudder pedals, minimal and exact responses to the required challenge-and-response checklist read by the First Officer–and sipping my coffee. The jet feels loaded up; weighty. You can feel the 112 feet of wing out there, the 40 foot tall rudder buffeted by gusts. Definitely an airship lumbering on the ground. Radios and official responses; taxi clearances and I say “okay” as soon as they’re given so my F/O knows I heard and understand.

Other than that and the radio chatter, silence. Because I don’t want anything on the Cockpit Voice Recorder (CVR) except for official, flight-related verbiage. There’s too much that could get screwed up, too much that needs to be checked before take-off to allow a layer of distraction. Plus, it’s the official policy: “sterile cockpit” below 10,000 feet. That is, no non-flight related talk, period. Saves the bubble, the concentration, for important stuff.

Sterile Cockpit.

Because here’s the problem with advanced flight automation: an input error, left undetected, can have disastrous consequences. A keystroke error can lead to faulty flight guidance commands, from the basics of pitch and bank to the routing errors. The only hedge against the hazard is diligent checking of all input. We did the route check at the gate, remember? Now we verify that the data-linked upload and our own inputs are valid: gross weight, center of gravity, fuel weight, take-off and abort speeds, climb speeds, every number associated with performance. That’s as we’re rolling, and as I’m ensuring we don’t violate anyone’s taxiway or runway space, steering with my feet–sipping my coffee, of course.

Ready for your eye test? "Give way to an RJ on Charlie, then taxi east on Bravo, short of Charlie 3."

Several numbers you must see, every time, before take-off–it’s not enough to have the First Officer read them aloud (“We planned 155,000 pounds, we’re actually 156,500 pounds . . .”). I will physically view the data-linked final weight numbers, I’ve already written the planned weight on my side panel clipboard as a reference, and I HAVE to see the correct number on the Control Display Unit screen. And at the same time, not taxi into the dirt or worse, any other jet. Not so easy at night.

But no worries–if it gets too hectic, timeout: “Let’s hold on the checklist here till we’re stopped.” Ever wonder why there’s a delay before take-off? While other jets are coming and going? Often, this is why. After leaving the gate, I’m completely detached from schedule constraints–we’ll get airborne as soon as all checks are thoroughly and correctly performed. As I tell F/Os when the tendency to rush starts to rear its ugly head, “We don’t get paid to rush. And if anything goes wrong as a result of rushing, no one’s going to be there to bail your ass out.”

Here’s where I like the silence, the bubble: no extraneous concerns beyond this flight. A departure path clear of weather and traffic. Verified speeds and weights in the flight guidance system, so the pitch and bank commands will be valid. But if they’re not, a mental review of what I know are the limits: greater than nine degrees of pitch up will drag the tail on the runway. Doesn’t matter what the flight guidance commands, my hands will not exceed a limit.

Waiting. Quick mental review of high-speed abort items: fire, failure, fear or shear. That is, after 80 knots, only an engine fire or failure, or my split-second judgment that I “fear” the aircraft is structurally not airworthy, or a detected windshear will cause me to abort the take-off before max abort speed, and after that–we’re flying with whatever we have.

I have options a hundred miles down the road, but also for liftoff: best single-engine climb angle, if we need it; left downwind to land south if we do. McChord 20 miles south with lots of runway. Fire and failure litanies. Mt. Ranier, all 14,410 feet of her, and where she is at all times.

Got it? 165 others are assuming that you do–so you’d better.

“American 116, line up and wait.” The tower’s direction. Real quiet now. Last minute runway checklist items. Ease in the power–there may be smaller jets behind us. Swing wide, line up on the center stripe; hold the brakes. Fire, failure, fear or shear. Minimum safe altitude. Engine failure profile. Initial level off altitude. No other thoughts. And no worries–this is gonna be fun.

Departure path is clear. “American 1116, cleared for take-off, runway one-six, wind one-five-zero at ten.”

“Rolling on one-six, American 1116.” All exterior lights on.  Another swig of java–we’ll get back to it on climb out–stand the throttles up; gages spring forward, then toggle take-off power on the autothrottles, hack the elapsed time button on the chronometer.

Both engines growl to take-off power–love that feel as they bite the air, compress it, mix in jet fuel and burn it, shoving us forward. Fifteen hundred miles to DFW–let’s get airborne.

Next Post: Part 3, enroute, and the landing.

aa

Turbulence: A Moment of Silence, Please.

Can we talk for a minute? I mean crew to crew? If you’re not flightcrew, this may be boring. Sorry.

But still, let’s talk about not talking for a minute. Here’s the deal:

We’re flying along fat dumb and happy. Then, it gets bumpy. I turn the seatbelt sign on. What do you NOT do? Or more accurately, what do I wish you wouldn’t do?

Call the cockpit. Seriously. What we get more often than not these days is, bumps, then ding-ding. “It’s for you,” I say to the First Officer, even though I am monitoring the flight interphone in my headset. Then I get the thanks a lot look from the F/O who reluctantly picks up the phone.

But I already know what the flight attendant’s going to say: “How long is it going to be bumpy?” or worse, “it’s really bumpy back here.”

Sigh.

First off, besides being an inane question, it shows a real lack of understanding of what just happened, plus what needs to happen. To begin with, if we knew the turbulence was there ahead of time, do you really think we’d fly into it? And given that we didn’t know it was there, how the heck are we supposed to know how long whatever it is we didn’t know about is going to last?

And truly, is it possible that it’s bumpy in back but not in the cockpit, so you really need to call and let us know?

Worse, either of us having to answer the phone with “we have no idea” or “yeah, it’s bumpy up here too” only prolongs the turbulence. Why? Because here’s what has to happen to get out of turbulence.

First, I have to decide if we can climb or descend. Are we light enough for a higher altitude and at that altitude, what is the margin between high speed and low speed stall? That is, a higher altitude may be habitable in smooth air, but not in turbulence–yes, the charts are broken out into smooth, light, moderate and heavy turbulence because it affects both speed control and the airfoil. Given that we are in turbulence at this geographic location, there’s a darn good chance it extends above and below us here as well.

If the margin between high and low speed buffet–Coffin Corner, as it is known–is sufficiently wide in my judgment, then climbing is one option.

The other is descent but that has a catch as well. Yes, the Coffin Corner spread is more favorable. But now we have to worry about fuel burn, which is higher in the denser air of lower altitude–which is why we cruise at the optimum altitude for fuel burn and Coffin Corner spread. I have to calculate whether the increased fuel burn allows for sufficient arrival fuel to accommodate the destination situation–and that varies.

Going into Omaha? Seldom if ever an arrival delay. Atlanta? Chicago, La Garbage? Better have flexibility and loiter time–which means fuel. Plus, the destination weather: with a low ceiling and visibility, even Omaha isn’t a slam dunk.

The final gotcha about descending to a lower cruise altitude because of turbulence is the increased fuel burn it’s going to take to return to the optimum cruise altitude when it’s reported smooth again.

With me so far? Then we need to call air traffic control and find out the ride report and the winds at a higher or lower altitude. Why? because a higher (or sometimes lower) altitude can have a significantly larger headwind, which again affects fuel burn, never mind arrival time. Anyway, calling takes time, then it takes more time for Air Traffic Control (ATC) to find the info we’re asking for.

Once we know the winds and the reported ride conditions, it’s back to a decision about up or down, based on the fuel endurance and destination weather factors I just explained. That all takes time too.

Once we’ve determined the best option, we request a new altitude from ATC, then wait for them to coordinate a new altitude–which also often comes with a catch: sometimes, they’ll need you to turn off course to gain spacing from another aircraft either in the airspace we need to climb through or at the altitude we’ve requested. Again, more fuel. Can we do that?

And then there’s the climb or descent itself: it takes minutes even after the minutes of calculations, requests and clearances.

None of that starts till we’re off the phone with you. Because in a two-man cockpit, both of us must be fully in the decision loop, as well as the execution of the changes in altitude and heading. And even then, we may find the new altitude is not smooth either–in which case the whole process starts over.

You can trust me on this: once we encounter turbulence, we immediately go to work to find a better ride. But none of this happens while you’re calling us. And we’d do it whether you called or not–so don’t delay the process.

If you’ve ever flown with me, you know this: if I know of any turbulence ahead, I’ll call back and tell you to “grab yourself a buttload of jumpseat–she’s gonna buck.” If I haven’t told you and it is suddenly bumpy–grab yourself a buttload of jumpseat–and wait for us to start the process of finding smooth air.

We’re definitely aware of the turbulence and looking for smoother air. All we need is a moment of silence.

Peak Experience

When I lived in Honolulu, over time I grew to take the visual for granted. That hit me one evening as I was taking out the garbage. Over my head, spread out like a splash of spilled paint, a furious crimson sunset vaulted across the sky.

Good thing I took out the garbage.

But that’s the way we get, isn’t it? Workaday world with an accretive ho-hum factor. What was wondrous becomes worn, routine and eventually, just another thing to do. If that’s the thing you always do.

Or maybe you’re a victim of circumstance. Used to marvel at a once-in-a-blue moon view of the gravelly dark volcano spine of Iceland during an Atlantic crossing or the blue sea ice sprawl of the Greenland fjords. Seldom did the weather or the route allow such a view, but if you were in back, you didn’t see it. That’s because the one time I made a P.A. telling the passengers to look off the right wingtip and behold the marvel below, it was only a matter of seconds before the flight attendant purser crashed through the cockpit door, livid.

“They all lifting their window shades to look out the windows!” she bellowed.

The horror. Not passengers looking out the windows at an incredible view; rather, the bloated and reddened face of the flight attendant chewing my ass. “Now they’re all going to want stuff! That’s why we’re running the movie!”

But still. This is where I’m a bad dog: I still will tell you when there’s something wondrous to see. Like yesterday–and here’s my not noticing the sunset till I take out the trash–I was hassling with an air traffic control clearance, a balky fuel boost pump, and crosschecking the weather radar when I happened to notice this right in front of my face:

Mt. St. Helen’s north face–blown off in 1981, buried in recent snow but the story’s clear enough, isn’t it? Stupid me for being heads-down, just another departure with a little fuel imbalance and navigation hassle thrown in. But there was more.

St. Helens’ big sister, Ranier looking stately as ever with a 14,410 stature of quiet dignity.  Almost missed that too, but truly, she’s hard to miss.

Especially if you’re allowed to look. Who’s stopping you? Well, who’s stopping me besides me? What is it about chores that take your focus until someone tells you to open the window shade and look? And life goes on nonetheless.

Further south: Hood!

God we have a lot of pointy stuff in this country, don’t we? In fact, take a look at the carpet of rocks that is the Sierras. I can’t even imagine the cajones of those who crossed this monstrous tract on foot.

And it’s not just the peakish stuff–we have magnificent ditches, too. The Grand Canyon sneaks up on you too, embarassing those who don’t notice until the trash is full that there are wondrous things silently waiting to suck the breath out of you.

And let’s nod to civilization. Now and again, a concrete ridge pops out of an undercast with man made peaks and valleys of vertical beauty:

Even if there’s nothing to see outside–there’s still something! Like these clouds which, from seven miles above, look more like sand dunes than anything, sprawling five hundred miles in all directions.

And you want dunes? We have real dunes too. If you were on the ground, this would be a nasty sandstorm in Arizona, wouldn’t it? But from the heaven’s eye view, this is a beautifully painted, delicate marzipan.

Is that just life or what? Isn’t it so that there’s much furious and breathtaking life spinning by below that we don’t even notice while we have our head buried in work and hobbies and distractions and stuff?

Sure, there’s always the office. Always work. But.

There’s more, too, isn’t there? Wheeling by silently, below, waiting but not caring if you look or not–it’s your loss, right?

Yes, that’s 619 knots–over 700 miles per hour.

Life comes at you fast, doesn’t it? Or more realistically, goes by way fast–whether you’re looking or not. Lift the shades, for god’s sake. Screw the fat woman yelling inside to close the shades and watch the damn movie. Worry less about the boost pump–we can balance fuel later–and take a breath between radio negotiations with air traffic control to look down.

It’s all going on, and going by, my friend. Have a quick look–because that’s about all you’ll get before it’s gone.

Holiday Travel Weirdness: The Jethead Chronicles.

What is it about holiday season travel that brings out such weirdness? I’m not just talking about the vagrant standing out in front of our favorite Seattle crew hangout with the helpful sign:

He also offered to be my “bodyguard” for $5, but I was with Ben The Dependable Copilot, and Ben’s about 6′ 2″ and weighs in about 220, so I passed. But still.

And even Pike’s Market Place was a little off the game today as well:

So just getting away from the airport doesn’t seem to limit the weirdness this time of year.

Now, at the airport, odd stuff is a given. That’s because odd people still have very little time and so must go by air, I suppose, to share their weirdness with family and friends.

Some folks just don’t get out much, but this being the holiday season, they’re of necessity heading to “somewhere else” and you know what the fastest way is from point “A” to point “B,” right?

Maybe there’s too much of a good thing on either end–eating, drinking, whatever. Problem is, airline crews are kind of stuck in the middle: between wherever “here” and “there” is for the traveling public, our workplace is the waiting room.

I guess folks just make themselves at home, or forget they’re not at home. Either way, our “workplace” is more bizarre than ever during the holidays as a result. The trick is to not only act like you don’t notice (step around the seemingly dead body for whom apparently stretching out on the floor is fine), but to try to act nonchalant when you do–which sometimes is difficult.

The on-board weirdness is predictable, with holiday travelers who are often infrequent flyers. Go ahead, mop the lavatory floor with your socks, Mr. Seldom Travels By Air. I don’t want to even think about it, but I am grateful that at least somebody’s cleaning that outhouse floor, even if the flight attendants are gagging when you do.

Or, go ahead and ask if there’s food on this flight. Has a nice, nostalgic ring to it, especially since there hasn’t been a meal served in coach this century.

I don’t mind for two reasons. One is because no matter how many times airlines, air travel organizations or even travel agents tell you that you need to bring your own food (and water if you want real convenience), you’d rather be surprised.

And second, the cockpit door is locked from the inside, so you can’t see what I’m eating anyway

Whoo-hoo: hot fudge brownies for the crew!

and really, you wouldn’t want to know anyway.  It’s pretty scary up front. Right?

No, honestly, what it is is peaceful. Darling Bride used to come up to the cockpit when we were flying at night and say how it was a cozy cocoon. It is, and I appreciate that–especially compared to what goes on in the back of the plane.

Phoenix glides by 7 miles below.

Gives you time and silence to put things into perspective. When you do, you realize that holiday travel is the best: it’s more than just business or even vacations. It’s families; it’s reunions and gatherings and children. It’s not just air travel, it’s yearlong anticipation of children and adults alike.

Our Chief Pilot–a true leader who voluntarily flies  on every holiday–uses this example to explain: The CEO of Revlon once said, “We don’t sell cosmetics–we sell hope.” Truly, what we do in these holiday travel weeks is just as magic: it’s hope for many, joy for the kids and for the adults who love them.

Come to think of it, weirdness and all, this is a great time of year to be an airline pilot, to fly families and friends to reunions and holiday gatherings.

I’ll be in the air this week–next week too, looking to make somebody’s travel as quick and easy as possible so they to can be with family and friends for the holiday. Really, it’s the least I can do considering they’ll mop up the lav floor without even knowing it.

Songs In The Key of Flight

It’s definitely the Giddy-Up Chorus howling out there on the wings as soon as you press that Takeoff Power button on the throttles. Last eastbound flight out of Las Vegas, so we’re pretty light–everyone’s either already beat it out of town or is still in a casino somewhere trying to break even. Although they don’t realize it, in Vegas that’s winning.

Funny thing to pop in and out of that world so briefly. For me, it’s all about getting in between the other air traffic and the mountains, then getting out as quickly as practical, around those mountains, then climb as high as possible to ride that jetstream tailwind home.

During preflight, the cockpit sounds like an orchestra pit before the show, with hydraulic pumps whining like a string section warming up, the kettle drum thud of cargo loading, then huge doors locking shut. The forward galley door whomps open with a blast of fresh air and the clatter of catering carts trundling on and off the plane. Two flight attendants try to squeeze into the cockpit and huddle against the swirl of cold night air, mixing their chatter with the drone of air traffic control on two radios on speakers overhead.

We’re all in matching polyester costumes, waiting for the curtain as the audience troops in: the edge of night travelers, worn out from whatever they did in Las Vegas, resigned to arrive on the east coast at dawn–I’ll take them halfway there, then hope to dodge the wrong way drunk drivers on Airport Freeway to get home myself after midnight. It’s an easy crowd leaving Las Vegas–out of money, out of vacation, often hung over. The exact opposite of the inbound crowd.

Had lunch myself hours ago and a thousand miles away. My fortune read “you will travel with the person of your dreams.” Is that what they’re doing in the back? It’s hard to remember when you’re work is travel that in back, it’s a passage to somewhere or from somewhere and some one. And the person of my dreams is two time zones away, getting ready for sleep, but never too far from my mind.

Huh? My First Officer? Guess I won't use the lotto numbers.

We’re going through our lines carefully, checking that everything’s in order, all systems performing as they’ll need to for the next thousand miles. He reads, I check, I answer, he confirms. It’s all too complex to just have at it. We’re careful now so as not to have to be “resourceful” later.

The agent announces curtain time: “Everyone’s on board–okay to close up, Captain?”

I thanks the agent for the good job boarding the flight–whether it’s good or not, I just know they’re hassled and need a pat on the back. Then it’s show time: places, everyone, places! Lap belts, shoulder harnesses, crank the rudder pedals forward to get full throw. Don the headset, adjust the boom mike and wait for the cue from the ground crew. “Chocks are pulled, everything’s buttoned up, we’re ready for brake release when you are, Captain.”

Glance to the right at the warning lights on the overhead panel–trust but verify–to ensure all the cargo doors are closed. “Brakes are released, stand by.”

Glance to the right again. “He says they’re ready downstairs.” That’s the First Officer’s cue to call ground control for pushback clearance.

And now it’s time to strike up the band. “Turning number Two,” I say, hacking a clock to time the start sequence.

Gonna take a big bite out of the night sky, aren't we?

Valves respond to the switch I just twisted, channeling high-pressure air into the huge turbine section. It begins to moan, vibrate, whirl; one of my favorite sounds in the whole world: a jet engine starting. Never ever tire of that sound.

The left engine joins the symphony. Numbers tell me they’re both in tune: 20% N1, 40% N2, 600 degrees Centigrade at idle, 800 pounds of fuel per hour. Oil pressure. Hydraulic pressure. Electrical power from the generators. Amen.

They’re a perfectly tuned duet, and they’ll spin at 30,000 rpm for as long as we have jet fuel and oil, the latter as much for cooling as for lubrication. From behind, a virtual blast furnace: I’ve seen it, taxiing behind another 737; a devilish smelter glow–you can actually see the ring of fire if you’re close enough.

We join the parade of floats with winking lights rolling toward the runway. More numbers along the way in a litany of challenge and response: planned weight, actual weight, power settings, speeds, distances, maximums, engine failure routes and safe altitudes, minimum climb gradients, hold downs, departure speeds, obstacle clearance altitudes, initial level off. Crosschecked, crammed into my head.

The cockpit’s dark save the instrument glow. I transition to ghost vision, as I call it: the Heads Up Display–or HUD. Everything on my primary flight display is projected on the glass in front of my face so I never have to look down in flight.

But instead of the multiple colors that help separate function, everything’s a ghostly glowing greenish aqua. And it swims: the airspeed tape runs upward like the dollar signs on the gas pump. Then when we lift off the right side begins to jump with altitude and vertical velocity.

Can’t get lost in it, mesmerized–there’s a jet to be flown. Take it in subconsciously, they tell you, just fly and hold that in your peripheral vision.

It’s all in your head as you roll down the runway chanting to yourself fire, failure, fear or shear. After 80 knots, that’s all you’re stopping for, so it’s all you’re looking for: engine fire, engine failure, a “fear” in my judgment that some structural failure has left the jet unflyable (good luck determining that at 150 mph) or windshear.

Luke, I'm your FATHER . . .

I’d rather handle everything else in the air. Since we’re lightweight tonight, when I shove the throttles up and hit the “TOGA” (Takeoff-Go-Around”) power button, we leap forward. The wing slices the air and rises. A half dozen computers sing to themselves and each other, figuring fuel flow, engine temperature and pressure, wind speed and direction, ground speed–the engines snarl and buck.

We lift off.

Ghost vision tells me the lift vector, the flight path, the course, the wind, our speed, our climb performance, compass heading, on-course tracking and deviation and a hundred bits of changing information. Hands and feet on ailerons and rudder, I trace a line in the sky invisible to everyone except for me, and anyone on the ground watching the arc we inscribe in the sky, strobes flashing, running lights and exterior spots like an arc weld in the sky.

I can see it; I live and breathe it, day after day after day. And if you listen, you can hear it too: riding the righteous fire, we sail off in a buzzing roar of high by-pass fanjets hurling us up to the forty-thousand foot level, the final act you can see from the ground: a tiny speck of light that arcs up and away, taking the show far and away at five hundred miles per hour.  A contrail in the moonlight, the song plays on, the chorus that carries us home.

The TRUTH About Flight Attendants.

You sure you’re ready for the truth?

Still watching “Happy Days” reruns? Or maybe even “Leave it to Beaver” (okay I do, but I already have seen behind the curtain when it comes to Flight Attendants) where June Cleaver vacuums in pearls and heels? If this is you, please click here. Okay, don’t say I didn’t warn you.

First, let’s start with the basics: who IS this person we call Flight Attendant? Where do they come from? Actually, they’re parents and spouses and significant others and sons and daughters. And they come from, well, everywhere.

My friend Melissa and her crew.

The common denominator seems to be the ability to get along with nearly anyone. That, plus the ability to handle children. No, it’s not that they handle children on board in their role as Flight Attendant. Rather, they must deal with a lot of childishness in flight on both sides of the cockpit door. So anyway, many, it seems, have a background in Education: either  as a college degree or as a teacher–or both.

My friend Nanci dealing with one of the children on board.

But that’s just what constitutes a significant number, but by no means, the majority. I once dated a Flight Attendant who had previously been a USDA meat inspector (I got rejected as “Not Prime,” although I’d like to consider myself at least “Average Chuck”), I know several with PhDs, I know one guy who flies for my airline who is an M.D.; the bass player in my band (shoutout to Angela!) is a flight attendant; My Darling Bride (MDB) before she became a “stewardess” was an engineer.

Okay, WARNING: don’t EVER call them “stew;” they hate it–even though my own mother, even after 25 years of non-rev travel on my passes still calls me to say, “The stews were so nice.”

Thanks, Mom.

But I can use the term myself because MDB doesn’t listen to me any more and in fact, with Flight Attendants you could say anything you want on the aircraft P.A. and they’ll NEVER KNOW. Seriously–the P.A. is a frequency that they can’t hear–kind of like a reverse dog hearing–so I could announce “I slept with your sister!” on the P.A. and she would simply ask, “what time are we landing?” Because she didn’t hear that P.A. either. But I digress.

Let’s just cut to the chase: here’s what you really want to know. In fact, let’s just go over important facts you NEED to know if you’re going to deal with flight attendants (of course you are, in flight), or date a flight attendant (you THINK you are, but that’s in YOUR dream, not theirs and they don’t get much sleep these days anyway), or maybe even you want to BE one (What, you’re finally off suicide watch, now this? Break the Prozac in half). Anyway, learn THIS:

1. Flight attendants will kick your ass. Seriously, they can and they will if they have to–and trust me, I’ll explain later–you want them to.

Okay, Carolyn's actually one of my Facebook friends and she's very nice. Mostly.

I’m not kidding. If you piss them off, you will pay. It might be be something simple like overfilling your coffee cup purposely so you’ll have to spill it (that was one of MDB’s specialties) or even the patented Flight Attendant “eff you” that is given so subtly and sweetly that you don’t even realize till the cart and flight attendant are three rows back before you think it through and realize, “Hmmmm . . . I think I just got told to go eff myself.”

Not that you don’t deserve it: they’ve asked one hundred people before you the same simple question–“What would you like to drink?” And they’ve answered the what do you have question at least as many times, plus they made a P.A. giving you the answers ahead of time. So, when you in row 32 ask again anyway, they have a soothing, pleasant proximate answer that after a few minutes your brain finally deciphers correctly as, you stupid idiot, YOU SHALL HAVE NOTHING. To which I would add, “you douchebag” but Flight Attendants are more skilled and less vulgar than I am. Bottom line: don’t be an idiot.

2. Flight attendants will share their ass–and they are crafty. We’re all crammed into a long, sealed tube, right?

Let’s face it–you’re in a sardine can for hours on end. In the cockpit, I actually have separate zone-controlled (by me) air conditioning and recirculation. Yes, it is good to be captain. And sure, you have some weird ideas about what goes on beyond that cockpit door, don’t you?

Suffice it to say that we pilots get “the royal treatment.” Now let’s move on.

Back to the long metal tube you’re paying a few bucks to be trapped in rather than face the freeway for days on end getting to whatever destination you’ve coughed up your vacation savings for.

The air in the jet is fine, it’s just the people like you who muck it up with your coughing, sneezing and personal exhaust if you know what I mean and I think you do.

Well, the cabin is their workplace, too.  As long as they’re trapped and required to endure assorted emissions from both of your ends (sometimes you’d have to think that the ones from your south end are more tolerable than the “what do you have?” stuff coming out topside), they deserve a chance to defend themselves. And when you travel, especially as much as we do on a flightcrew, diet is at best a catch as catch can thing. That end result is bad, eventually.

Wet cleanup on aisle six.

And the best defense in this case as in most others is a good offense.

Hence, “crop dusting.” That’s the diabolical plan by which they spray front to back on board so that by the time you get smacked in the face

"My god--air, please . . . !

. . . they’re already halfway to the aft galley and out of sight. You all will blame each other, but there was, you should know, a secret plan:

From the Flight Attendant Manual: "Always cropdust front to back."

There’s nothing you can do about this, by the way, except take small breaths. Deal with it.

Finally, here’s the last and probably most important thing you should know:

3. Flight attendants will save your ass. And that’s what they’re on board for–not just to tell you what beverages are available, not to entertain you, but actually to save your ass in the worst possible moment of your life.

Notice who isn’t walking away from this crashed aircraft alive and well? It’s the Flight Attendants who helped them off and are still on board helping others. That’s what they do. And that’s why you want them to be able to do item #1 above: they need to be able to throw your ass down an escape slide if you can get out of a burning passenger cabin yourself.

They can handle the 90 pound emergency exit door or the even heavier cabin doors. They know the route by feel and by heart to the nearest emergency exit in a smoke-filled cabin–and they’ll take you there. They are ready with first aid and CPR and a defibrillator and a fire extinguisher and oxygen and anything else you or I might need in flight. Not what we “want” in flight, although they take care of all they can–but most importantly, what you need to make it off the plane alive in any circumstance.

That’s the challenge they’ve undertaken on your behalf. That’s what they’ve trained to do, what they’re tested on and certified annually and rigorously through drills, classes and study.

They’re not leaving without you, even if they have to haul your ass out of a burning plane themselves. To me, that’s amazing.

This they do for minimal pay over long hours with little time for food or sleep and with complete disregard for time zones or body clock, because that’s just the nature of the job. I’ve never known a more selfless group, and there isn’t a more versatile group of professionals on the planet. They can hang with anyone, talk to anyone, and they’ll save the life of anyone, in the air or on the ground.

Do I have to spell this out for you? You should respect and appreciate the unique and giving individuals who are the flight attendants on your flight. Or in my case, I appreciate the one who is my partner for life. Or there’ll be an ass-whuppin’ in short order for you and me alike.

Got it? Good–remember it. Think about the big three flight attendant truths I just shared with you the next time you fly.

And be sure, if nothing else, that you know what you’d like to drink BEFORE the cart gets to you. When it does, “please” and “thank you” are mandatory–especially to the professionals who can both kick your ass and save it, and who will do both as necessary.

And THAT is the truth about Flight Attendants.

Epilogue:

Actually never met the guy, but you gotta like the way he thinks.

Coming next:

You hear the name, you see the pilot, but who is this person, “the airline captain” in whom you place your trust?

The exclusive, only here. Subscribe.

From Sea Level to 737 Captain: The Good, The Bad and The Ugly.

[Note: this is part of a continuing series describing what it’s like to become an airline captain on a brand new jet. Want to start at the beginning? Click here.]

.

Midway through the simulator phase and there’s plenty good, some bad and a lot of ugly.

But the latter stuff, that’s just your perspective as a pilot. What the hell do you know?

Overall, it’s good to be handling hardware rather than clicking a mouse and watching animation. But there are rough patches. You can’t find anything. Reflex guides your hands to the wrong place: need a wider Nav display range? That’s not where it is. Looking for a map light? Uh-uh, it’s over there, not here, and it can’t exactly reach anyway.

And the HUD: a thousand bits of information before your eyes. But it’s all displayed in lime green, largely negating the symbol sorting aide provided by colors (red, warning, yellow, caution, green okay, blue, advisory) on all other displays. Plus, what doesn’t fit on the display is converted into a number: the all important radio altimeter hides in among a cash crop of abstract digits rather than as a moving display. But half of what you need to call for is based on its countdown–or up.

Here’s you on the controls: take it easy . . . what is this with the power steering? You’re flying with hamfists and pork brains, or at least that’s how it will feel in the back of the plane.

From the movie Airplane:

Gunderson: “He’s all over the place! Nine hundred feet up to 1300 feet. What an asshole!”

Ever fly a plane before? Well, yeah–the last 19 years on the MD-80 which handles like a pig in both pitch–especially pitch, being a long tube, and with un-powered ailerons. The 737 is a Maseratti by comparison. So you feel like a klutz, wing-rocking down final because it’s so sensitive–and you’re not. Which brings out your inner teacher:

Maddog jocks, you know the drill: put some smash on the jet, aim it at the runway. Cross the  threshold at fifty feet with a plus-five knots (I always did; admit it, you do too) over V-Ref  speed then snatch off all the power. But not in the Boeing.

And you’re your own worst critic. The real teacher? The Simulator Instructor? She’s great; real laid back, very calming demeanor in the briefing and in The Box (which is what we call the simulator). You learn better that way, the way she is: confident, knowledgeable yet very easy-going.

Cleared for the approach, read the fine print.

Still, need a conversion course for MD-80 “steam jet” pilots. But you’re figuring it out: LNAV VNAV is smart box stuff–FMC driven.  Where’s the IAS and vertical speed? Ah, there’s the magic.

But practically speaking, the hours in The Box are beginning to add up. Here’s what week one of the sims reveals:

1. You’ve become lazy as a pilot because there was no challenge to the same old Flintstone (do I really need to spell this out? PREHISTORIC Douglas jet) flight deck for too many years. Time to update and rethink the concepts such as Category III approaches hand-flown to a 50′ decision height (YGTBSM), 600 RVR, vertical navigation, and how twenty-first century technology has changed flying.

Simulator instructor's station. Right behind us; pay no attention to the woman behind the curtain.

2. Boeing has made a stable hand-flying jet. That’s a good wing, a dependable airfoil. Feels substantial both in the flare and on rotation. Not so much lion taming with a whip and a chair like the MD-80. Plus power to spare, on the wing.

3. With the state-of-the art technology comes the challenge of lawyers and liability. Now procedures are driven by what just happened in court regarding some type of aircraft accident.

Anyone can fly like a pilot, but now you need to fly like an attorney. So many new restrictions and procedures that you can tell stem mostly from legal considerations and absolutely not from good flight practices. But that’s just the twenty-first century, right?

Still, so much to absorb, especially in the left seat: you’re going to sign for this jet and everyone on board in about ten days. You have to get this right, not just to pass a check, but for what you know is coming: that dark and stormy night when things start going to “the top of the pyramid:” options narrow, no way out, it’s up to you to out think and outdo whatever nasty situation that will–not might, will–test you in the air sooner or later.

Funny thing: flashback.

Pilot survival, from so many years ago. Back then, a “double-bang:” fly two sorties, back-to-back; formation, aerobatics–you name it. In between, a Coke and a bag of peanuts for you. The Coke had both caffeine and sugar to pep you up. Same deal now, at midpoint in every simulator session, in the Iron Kitchen now, in the Squadron Snack Bar back then, face still showing the outline of an oxygen mask, hair matted from a helmet.

Now, the Iron Kitchen is just an alleyway between simulator building, filled with vending machines and a few tables. It’s the crossroads of airline pilots all somewhere in sim world, whether on the break between sim periods on a check or like you, between training sim sessions. It’s the company of pilots at once lost in their own reverie about their sim check or like you, the right steps into a new jet, shooting the breeze, hangar flying, griping, laughing but regardless, it’s the folks who fly.

Just like back in the Air Force, the peanuts good and salty to put something on your stomach quick, then back to the struggle with an unruly jet that wants to get the better of you.

It didn’t then, and won’t now either. That I promise; I promise me, promise you. Believe it.

Coming next–and in the next installment of this blog: final preparation, the the FAA rating checkride. Stay tuned . . .

Back to the Future: From the Ground Up.

Have to warn you: this could be boring.

Because you’re on another journey: forward, which in a way is backward, too.

Been sitting here for twenty-ish years. Thousands–fourteen thousand plus change, actually–of hours of pilot time in this jet. You know where everything is by feel. Could do most functions with your eyes shut. Thousands of approaches and landing and take-offs and cruising.

All that ended Friday.

Buh-BYE, MacDonnell-Douglas, hello Boeing. Nice the way Boeing incorporated the Mac-Doug logo after eating the company whole, don’t you think?

But to get there, to move to the 737-800 captain position from the MD-80 captain’s seat: transition training. And there’s the time machine.

When did you do that last? 1994, for a brief stint on the F-100. And that school, that airplane, was a cake walk.

Back in those days, well, back “then,” new aircraft, new systems and procedures–just a fact of life. Flight engineer school, then  First Officer training, then widebody DC-10 First Officer upgrade, then MD-80 captain, then F-100 Captain and then requal back as MD-80 captain all in the span of 6 years.

That was just the way of the world: just do whatever it takes to fly the latest jet.

And before those days, an even faster whirlwind of flight.

Just a kid, twenty-something with a comparative (at least to today) handful of flight hours blasting around with my hair on fire. It was all just good fun and the training part? Just something you had to do–a nuisance, really–to get to go fly. That was fun, despite the responsibility of study and learning and proficiency.

It was all about the rush of flying, the freedom from the mundane office world, a desk and god forbid, a boss breathing down your throat. In the air, it was all pure exhilaration, freedom, power, and what the hell was I thinking, below, being barely 21 and flying solo with about 8 hours total, with a camera in one hand?

 

What the HELL was I thinking?

 

Back in those days, ironically, the buzz phrase was “fly safe.” Not sure we really did, but we said that a lot. Now, it’s a more appropriate “fly smart” in my mind, because that’s safest, really.

No doubt this place on the verge of more flight school and newer, bigger, faster jets is now as it was then a bit of luck: you’re just some guy, nothing special, who’s been lucky enough to be put in the right place, this place, where once again the top of the line jets and equipment at a major airline are there waiting for you to start.

There’s the link with the past: I still marvel at the opportunity, the good fortune, to have another jet waiting, to have a spot on the roster of airline captains flying it, to have a training slot and instructors ready to help me through all the steps and hurdles between now and forty-thousand feet.

And there, too is the connection with the mundane: studying manuals, learning procedures, memorizing technical limits and emergency procedures. Cockpit drills, procedural trainers, simulators, classrooms, evaluations.

I used to do all that as a matter of course?

Of course.

And here we are again. You wanted to stay out of an office, away from a desk, right? Been free of that scourge since college, and that was a different kind of desk. You’ve never had an office or a desk, really.

So here’s the alternative. Starting tomorrow, this blog will go through Boeing 737-800 school from Day One to first flight.

Might be boring. Might not even be able to make a blog of it. But, the connection of past and present, the reentering the past way of life–climbing over hurdles and obstacles–to get back into the air in an even more exciting way.

How’s that going to be, devouring new technical data, mastering maneuvers in a new jet, in full-motion, stage-3 simulators? Out with the old hand-flying feel, in with the new: airfoil’s different, controls all hydraulically boosted, no doubt a Boeing’s going to fly different. State of the art navigation (thank God, at last) to learn, new operating philosophies.

Can you master everything required to be certified as captain in flight with 150+ bods-on-board, never mind the $50 million dollar jet and the responsibility for both? In a few weeks?

That’s going to be past plus future, at least for the present. Interested?

It all starts again tomorrow. Let’s go.

Waltz in Blue: Last Dance with the Old Girl.

She was my first. And it’s true: in flying, like many other areas of life, you always remember your first.

It was a long time ago when we were both a lot younger, newer to the airlines. I’d read about her even before that, though. She was the sleek new model–long lines, long legs.

I looked down on her at first, at least from where I was, flying the DC-10. There was no mistaking her distinctive tail and shark-like profile.

I sat sideways on the DC-10, The Plumber, for a little more than a year and I saw her around–knew someday we’d get together. I wouldn’t be a flight engineer forever, and she was the “first date” for a new First Officer.

That’s the first “first” I shared with her: my first flight as a First Officer. For me, that was a long awaited milestone. By then, I’d been flying jets for nine years, seven of them in the Air Force.

But finally, after a couple years flying sideways as flight engineer, and six weeks of transition training, hours upon hours in full motion simulators, this was the baptism of fire: take-off with a full boat–130 plus crew–fly to Long Beach, land.

What a view, finally, from a front seat! All the way across the country, thinking about that landing in Long Beach. First time for me in a Super-80, and with a full boat. We worked it out; she made me look good, touching down firmly but in Long Beach, with a fairly short runway, that was the right thing to do.

And that, as I said at the time, was a dream come true. We did a lot of miles together, saw most of the country and a lot of Mexico, too. Good times, some of them on days I’d rather have been at home. But we hung out together on more than one Christmas, many holidays, even a birthday or two over the years.

Thanks, Marsha!

All told, I guess I accumulated a couple thousand hours in that right seat. Learned a lot about “big picture” airline life on my own, but most of the important flying lessons, like how to land on a slick runway, in near zero visibility, how to pick through a line of storms, wrestling with crosswinds and treacherous icing and a thousand little ‘gotchas” I learned hand in hand with the 80.

Then a couple years off to fly the big brother–the DC-10–all over the globe. But I took with me the early lessons I learned on the smaller, thinner “Long Beach Sewer Pipe” and put them to work on a grand scale on the wide body jet where often, I was glad I’d figured out how to accomplish the mission on the 80 first.

Which brings me to the second first: the Big Kahuna.

Captain’s wings. I can see plain as day still my first landing in the left seat at Raleigh-Durham, thinking similar thoughts from the first “first” in Long Beach years before, landing the MD-80 for the first time: that was a dream come true, too.

Now that’s where 19 more years have passed. Day, night, good weather and bad–you name it. The airline records show over 11,000 captain hours in this one spot.

And actually, the other seat, too, wearing yet another set of wings:

Instructor and evaluator. Helping others make their airline pilot dreams come true and as importantly, keeping the dream alive by ensuring the quality of of training in jets and sims for a couple years.

We’ve seen a lot of miles together in the air. Carried thousands of passengers safely over the years. And we’ve crossed the country enough times to span the distance to the moon, enjoying  the view most of the way.

Which brings us to the present. And more significantly, this week.

It’s the Last Dance with the MD-80 for me. It’s been a good twenty-plus years and many thousands of hours in the air.

But . . .

There’s a new girl in town. In fact, we get a new one every month, and that rate is actually going to pick up in the new year.

She’s state-of-the-art, more powerful, lifts more and cruises both higher and faster. She’s actually replacing the faithful old MD-80 which one by one, month by month and actually two by two, heads to the desert to park for good.

So this week, instead of another first, it’s going to be our last. Three more days and maybe another few thousand miles together.

Then when I put you on the deck this week, it’ll be for the last time. That’s going to be a little sad in many ways, but that’s the way it goes, right? People want to fly on newer jets and even beyond the fact that I can’t blame ’em is the reality that I do too.

In fact, I’ve already started learning the 737-800 systems, although my formal classes start in mid-month. Lots of new numbers, systems and procedures to learn.

And the new Boeing will be just a transition relationship for me. In a couple years, I’ll throw her over for the 777.

That’s the way it goes. Will always have a soft spot for the old girl; she was always faithful and a great dance partner. It’s going to be hard to park her for the last time Friday, but whenever we pass in the sky–and I know we will–we’ll share a good thought, a good memory just the same.